Winter storage

Any General info on Mechanics based on 'all' bikes...

Moderator: Staff

User avatar
menzies3032
Site Moderator
Posts: 3789
Joined: Apr 21st, '13, 20:48
First Name: Robert
Location: Teignmouth, Devon

Winter storage

Post by menzies3032 »

Well for me that’s it now..... the temprature is below 10 deg in the days and dropping to 0 ish at night. There is now a regular level of rain about and I am seeing road gritters on the motorways and trunk roads..... for me the fair weather sports bike rider that’s it now until March / April 2019.

So started to prep the bike for the winter and wanted to share what I do.
I am sure others will wonder why but hopefully this will help somebody.

To start give the bike a good wash and get all the road grim off (so grim does not damage the bike in the next months)
Then a decent Shammy off to get rid of all the water.
Then I use a bike protector spray to make sure the last of that water has gone.( making sure nothing is going to rust)

Next it’s sort the chain..... find a rag and grab the wd40
Spray the rag with WD40 and this gets rid of all the crap off the chain
Then spray the change with chain cleaner to get this bits you could not get to with the rag and to get rid of the WD40, then a good over the top spray of chain oil to make sure it’s not going to rust for the coming 6 months.

Then bike to disappear into the garage.

Then time to protect the tyres. Years back I left the bike on the floor and the tyres went hard and were total crap by the new year. Soooooo
1. Get the bike off the floor on paddock stands
2. Next drop the tyre pressures down to about 20 so the rubber is not under pressure without being used.
3. Find your oldest and crap tyre warmers (or the worst you can find on eBay) and put them on the tyres and leave them there. Don’t plug them in. Just give your tyres a little body warmer

Next plug the bike into a battery optimiser of some sort to keep the battery charged and fresh for next year.
Apply any and all chains and padlocks to keep the bike safe.

Then you can l leave it for the next month..... and then the 1st of every month do the same routine.

1. Chains and padlocks off
2. Tyre warmers off
3. Bounce the front forks just so you get movement
4. Spin the front wheel so the brakes do not stick to the disk
5. Pump the brakes to make sure the brakes work and release
6. Bounce the rear shock so you get it moving
7. Start the engine and allow the bike to warm up to normal running temperature
8. Whilst still on the paddock stand then at no more then about 3000 revs go up through the gears from 1 to 6 then back down again to neutral (helping to keep inner workings lubed whilst not riding)
9. Put your locks and tyre warmers back on
10. Repeated in a months time.

March is then servicing time. Buy your oil and filters and get it serviced ready for the 1st rides end of March beginning of April.

Hope this is helpful to somebody. If not hey hum.... just what I do.
Living in Teignmouth and riding a BMW F900R SE (in Suzuki blue colours :-bd )
Follow SWB on Facebook - https://www.facebook.com/South-West-Bik ... 4853502983
To receive SWB Whatsapp event notifications PM me your mobile number.
User avatar
billinom8s
Site Admin
Posts: 19883
Joined: Sep 10th, '05, 22:31
First Name: simon
Location: Teignmouth

Re: Winter storage

Post by billinom8s »

Bloody hell.

I've serviced both mine and am gonna make a point of riding them all through the dark months as i've not been able to for the Last 6 weeks.

Winter days can be good too.
07977507395
Image
don't forget we are onX and Instagrambelieve it or not !!!
southwestbikers@southwestbikers (original, I know.)
KTM 990 superduke R,
Zx10r trackbike, ktm 350 excf muddy
Suspension and bike work undertaken.
User avatar
Robbo87
Learner Driver
Posts: 2758
Joined: Feb 13th, '09, 19:42
First Name: Phil
Location: Ottery St Mary
Contact:

Re: Winter storage

Post by Robbo87 »

billinom8s wrote: Nov 3rd, '18, 23:55 Bloody hell.

I've serviced both mine and am gonna make a point of riding them all through the dark months as i've not been able to for the Last 6 weeks.

Winter days can be good too.
Wot he said - except for the servicing bit; I do that when funds & time permit.
Triumph Sprint ST 1050.
User avatar
Jug
Learner Driver
Posts: 1686
Joined: Jan 12th, '17, 13:44
First Name: Richard

Re: Winter storage

Post by Jug »

That is a lot of work... I can't say I've noticed any effects on a tyre from leaving the bike sat in the garage for 5 months.

Give it a good clean or the fly splats will turned mouldy.
Maybe give the engine area a blast down with some protective spray (FS365 or WD40)
Add a little more air to the tyres
Make sure chain is lubed
Once a month I connect the Optimate to top off the battery
..and that is it.

No starting the engine just for the fun of it. IMHO it's doing more harm than good, lots of engines don't like extended idling, and a few blips of the throttle is no substitute for a 20 min ride. What it will do though is advertise to the world that there is a nice bike stored in that garage. :shock:

Recently, due to having a garage that suffers heavily from condensation, I have taken to storing my roadies inside a makeshift tent with a 20W lamp under the sump of each. There can be condensation literally dripping off my trail bike but my roadies are bone dry in their tent. :x
1190 Adventure S, 990 Superduke, DRZ-400E - all the bases covered.
User avatar
scorcher
Learner Driver
Posts: 775
Joined: Nov 11th, '09, 20:59

Re: Winter storage

Post by scorcher »

690 is cleaned and parked up. Will stick it on the optimate from time to time but that will be it. 950 ready for winter duties. Will wash it occasionally, lube the chain occasionally and stick it on the optimate occasionally. Seems to have worked ok like that for the last 10 years.
User avatar
menzies3032
Site Moderator
Posts: 3789
Joined: Apr 21st, '13, 20:48
First Name: Robert
Location: Teignmouth, Devon

Re: Winter storage

Post by menzies3032 »

My baby tucked away from the horrible wind, rain and cold. :-bd :D
DA75BCCD-043B-49AE-9FA0-03CD16615A47.jpeg
You do not have the required permissions to view the files attached to this post.
Living in Teignmouth and riding a BMW F900R SE (in Suzuki blue colours :-bd )
Follow SWB on Facebook - https://www.facebook.com/South-West-Bik ... 4853502983
To receive SWB Whatsapp event notifications PM me your mobile number.
julesh
Learner Driver
Posts: 325
Joined: May 28th, '16, 23:46
First Name: julian

Re: Winter storage

Post by julesh »

She needs a duvet mate
User avatar
menzies3032
Site Moderator
Posts: 3789
Joined: Apr 21st, '13, 20:48
First Name: Robert
Location: Teignmouth, Devon

Re: Winter storage

Post by menzies3032 »

julesh wrote: Nov 4th, '18, 16:46 She needs a duvet mate
Hummmm might just add one =))
Living in Teignmouth and riding a BMW F900R SE (in Suzuki blue colours :-bd )
Follow SWB on Facebook - https://www.facebook.com/South-West-Bik ... 4853502983
To receive SWB Whatsapp event notifications PM me your mobile number.
Fozz
Learner Driver
Posts: 241
Joined: Mar 8th, '18, 07:09
First Name: Colin

Re: Winter storage

Post by Fozz »

The 595 is sorn and tucked away,the Xr is going to be ridden through the winter elements.
User avatar
billinom8s
Site Admin
Posts: 19883
Joined: Sep 10th, '05, 22:31
First Name: simon
Location: Teignmouth

Re: Winter storage

Post by billinom8s »

=))
You do not have the required permissions to view the files attached to this post.
07977507395
Image
don't forget we are onX and Instagrambelieve it or not !!!
southwestbikers@southwestbikers (original, I know.)
KTM 990 superduke R,
Zx10r trackbike, ktm 350 excf muddy
Suspension and bike work undertaken.
User avatar
Kata
Learner Driver
Posts: 1248
Joined: Aug 1st, '13, 21:27
First Name: John
Location: 'Nam

Re: Winter storage

Post by Kata »

I'd suggest putting a dust sheet over.

I've seen a few bike manuals that say to take the plugs out and put a little oil in each cylinder over the winter thought I've never done that.
Post Reply